POST 00858E : COMBINATION VACCINES, LYOPHILIZED VACCINES, DILUENTS AND VVMS
Follow-up on Posts 00847E, 00852E and 00855E
18 November 2005
_____________________________________
This posting contains three further contributions to this debate. The first
is from Rebecca Fields (mailto:
[email protected]) and the second from Andy
Tucker (mailto:
[email protected]) both from the United States. The
third is from Emma Uramis (mailto:
[email protected]) from Cuba.
_____________________________________
Dear Michel,
Very interesting question that you posed on Technet Forum recently.
Clearly, the cost benefits of this proposal are extremely attractive. So
far, I've seen conflicting opinions from Garry Presthus and Bob Davis.
You described a number of possible risky situations. One way to think about
the problem is in terms of two intersecting scales: one for likelihood of
the risk (i.e. of that risky situation occurring), and the other for the
severity of the consequences. If you plot the situations that you
described, they come out as follows:
1. Hib used with other diluent: severe consequences, relatively high
likelihood given lack of bundling.
2. Reconstituted product goes into DTP-HepB vial: severe consequences,
relatively low likelihood.
3. Health workers keep other lyophilized vaccines longer: severe
consequence, low to moderate likelihood.
4. Health workers ignore VVM, discard everything after 6 hours: consequence
isn't severe, likelihood is pretty low.
Two major concerns that affect these assumptions:
First, Hib and DTP-HepB aren't physically bundled. We've just heard from
one field staff that they're seeing more vials of Hib in the fridges than
DTP-HepB, raising questions of whether DTP-HepB is just being given by
itself without Hib for some reason.
Second, while training might be able to address this issue, we know it
often doesn't reach all who are actually carrying out the job and that
turnover is a big issue. So there would have to be very clear directions in
job aids or posters that stay at the facility. Given the possible risks,
these would have to be self-explanatory even to low literacy groups and
would have to be disseminated very conscientiously.
You mentioned the issue of vaccine labelling. Would vaccine manufacturers
be willing to support the proposed practice or would they feel it increases
their liability?
Best regards,
Rebecca
Rebecca Fields,
Technical Officer,
IMMUNIZATIONbasics
------------------------------
Michel
I used to work for PATH in Cambodia where I was the primary advisor to the
NIP on the introduction of DTP-HepB vaccine. Many of the logisitc and
practical issues of poorly-trained/low-capacity health workers in the field
are true. The one issue you didn't seem to raise is that the VVM on the Hib
vial may not be pertinent to the DTP(-HepB) diluent which may have been
kept separate and may be much further along toward "expiration." I don't
see a good solution for this unless the diluents can be assured to be kept
with the Hib vials and the Hib VVMs are "shorter term" than the diluents,
i.e., one can be assured that the diluent won't "expire" before the Hib
component. Sounds diifficult.
Best wishes,
AwT
Andy Tucker, MPH
Epidemiologist-at-large
Earth
More specifically:
Austin, TX USA
------------------------------
Hello Michel,
Regarding the considered risk that "health workers do get confused by the
new message and keep other lyophilised vaccines beyond 6 hours after
reconstitution", I agree that probability of occurrence may be low however
severity of effect could be very serious and in addition there is no
possibility of detection. Thus I think this risk is not acceptable because
failure may compromise children's safety then I recommend the proposed
practice should not be implemented.
Concerning your question on what text would be on the label of the Hib
vial, I would like to draw your attention to WHO/GMP text for final product
identification (TRS 908, Annex 4, item 15.11), which requires in addition
to the name of the product, at least the following information :
- a list of the active ingredients
- the batch number
- the expiry date
- and any special storage conditions or handling
So... how could be handled a recall from a specific batch of Hib vaccine,
if the vial is labelled as DPT-HepB-Hib?
Hope this can be helpful.
With best regards,
Emma
______________________________________________________________________________
_________________________
Visit the TECHNET21 Website at
http://www.technet21.org
You will find instructions to subscribe, a direct access to archives, links to reference documents and other features.
______________________________________________________________________________
To UNSUBSCRIBE, send a message to : mailto:
[email protected]
Leave the subject area BLANK
In the message body, write unsubscribe TECHNET21E
______________________________________________________________________________
The World Health Organization and UNICEF support TechNet21. The TechNet21 e-Forum is a communication/information tool for generation of ideas on how to improve immunization services. It is moderated by Claude Letarte and is hosted in cooperation with the Centre de coopération internationale en santé et développement, Québec, Canada (
http://www.ccisd.org)
______________________________________________________________________________